Cant get car to run - no spark

1991 MERCURY CAPRI
96,000 MILES • 4 CYL • FWD • MANUAL
Avatar
90SUPRA
  • MEMBER
  • 3 POSTS
I have been working on this car for a while. I got it free for a daily and all it needed was to be fixed. Was not running when I received it. Car turns over with no problem. Getting spark and fuel but no fire. The spark is orange. It seems like the car is flooding out but not sure. Backfire while cranking every now and then. I got a head off another cause my valves looked like they were not seating but that didn't fix it. The car is in time and still.... I cannot figure it out. Also got a used ecm off parts car. Please help.
Aug 3, 2008 at 4:59 PM
Advertisement
Avatar
MERLIN2021
  • ASE Certified Mechanic
  • 17,250 POSTS
  • ASE Certified Mechanic
The spark is weak, weather it's the coil, or the TFI module...should have a strong blue spark.

https://www.2carpros.com/articles/how-to-test-an-ignition-system
Aug 3, 2008 at 5:03 PM
Avatar
90SUPRA
  • MEMBER
  • 3 POSTS
I have a parts car and it was running when it wrecked. I got the dizzy off it, ignitor, head assembly, ect. I also bought new spark plugs... Do you still think its low spark?
Aug 3, 2008 at 5:09 PM
Avatar
MERLIN2021
  • ASE Certified Mechanic
  • 17,250 POSTS
  • ASE Certified Mechanic
If its orange it is...
Aug 3, 2008 at 5:16 PM
Avatar
90SUPRA
  • MEMBER
  • 3 POSTS
Okay. First I will try the TFI on the dizzy. But if its the ignitor then I'm pitching the car. I already tried 2 ignitors also.. I have too many projects as it is.
Aug 3, 2008 at 5:21 PM
Avatar
MERLIN2021
  • ASE Certified Mechanic
  • 17,250 POSTS
  • ASE Certified Mechanic
https://www.2carpros.com/first_things/car_cranks_but_wont_start.htm
Go here for in depth troubleshooting advice for your condition!
Put wrong link up sorry! Try this one...
Aug 4, 2008 at 12:53 PM
Avatar
DAVE53
  • MEMBER
  • 1 POST
I have no fire out of the coil to the distributor(hi tension) There is power to the coil and out of the coil(from ignition key in on and start position) I have replaced the coil with a new one$$$$$$$$$.
Apr 17, 2020 at 11:36 AM (Merged)
Avatar
JDL
  • ASE Certified Mechanic
  • 16,098 POSTS
  • ASE Certified Mechanic
welcome to the forum, I looked at 1.6 non turbo. With coil primary voltage both positive and negative will be hot with the key on. Engine cranking, the negative side should have a pulse, no pulse, check pickup coil in distributor. The ignition module may be attached to the distributor, that module is possibility.
Apr 17, 2020 at 11:36 AM (Merged)
Avatar
BSLICKER
  • MEMBER
  • 3 POSTS
Electrical problem
1991 Mercury Capri 4 cyl Front Wheel Drive Automatic

I have recently had a problem with lower spark about 5 months ago, replaced coil car worked very good till about 3 weeks ago. Then the car started out fine and then after a while after driving the car would shut down, I would pull over and the car would start, but once rpm got over 1.5 the car would shut down. After a few times doing this the car would then run fine for a while again, and then do this all over. Until finally one day it wouldn't do that so I check coil spark no spark. Replaced didn't help, replaced the ignition contol module, didn't help, Was told by ford dealership it was the pcm (main computer) so ok replaced that still no spark from coil. At witt's end with this problem, I have all the books and repair manuel's. One forum said camshaft senor, which i can not seem to find. Ordered the distributor coil ignitor should be in today... I see some schematic with a ballast resistor wire, no books tell me where that is either. If your fix does fix this I will gladly donate, but this is eating me up with people looking at it and parts with cash, so help if you can please...
Apr 17, 2020 at 11:36 AM (Merged)
Avatar
RASMATAZ
  • ASE Certified Mechanic
  • 75,992 POSTS
  • ASE Certified Mechanic
The only thing you haven't check is the distributor pick-up coil-you're getting a new distributor is this correct? If so its contained within-

The resistor wire powers the coil-check the coil positive terminal for battery voltage, none found the wire is open-the wire purposes is to reduce the voltage to prevent the coil from burning up-
Apr 17, 2020 at 11:36 AM (Merged)
Avatar
BSLICKER
  • MEMBER
  • 3 POSTS
I am not getting the whole distir. just the pick-up coil inside the distr. which should be in today I hope. I'll know in about a hr. I can give another update after I put that in hopefully this afternoon.
Apr 17, 2020 at 11:36 AM (Merged)
Avatar
BSLICKER
  • MEMBER
  • 3 POSTS
Well got the part in and replaced insiide the distr. that did not work, still no spark from the coil to the cap
Apr 17, 2020 at 11:36 AM (Merged)
Avatar
RASMATAZ
  • ASE Certified Mechanic
  • 75,992 POSTS
  • ASE Certified Mechanic
PICK-UP COIL
Check continuity of pick-up coil. If continuity exists, replace igniter unit. If continuity does not exist, replace pick-up coil.
Apr 17, 2020 at 11:36 AM (Merged)
Avatar
MIKE2KIM
  • MEMBER
  • 1 POST
no fuel or spark when hot ---------it cools down ist's fine
Apr 17, 2020 at 11:36 AM (Merged)
Avatar
LEGITIMATE007
  • ASE Certified Mechanic
  • 5,121 POSTS
  • ASE Certified Mechanic
have your crankshaft position sensor tested
Apr 17, 2020 at 11:36 AM (Merged)
Avatar
LEGITIMATE007
  • ASE Certified Mechanic
  • 5,121 POSTS
  • ASE Certified Mechanic
https://www.2carpros.com/car_repair_video/test_fuel_injection_pressure.htm

go here to test fuel pressure
Apr 17, 2020 at 11:36 AM (Merged)
Join 2CarPros for free, one of the most advanced car repair communities on the internet. From first-time drivers to seasoned mechanics, everyone is welcome to reply, share details, and get better answers. You can add a temporary image or video first; uploads are limited to 20 MB.
Ask a Free Question
Repair Safety Notice: This information is for general instructional purposes only. Vehicle repair can be dangerous. Verify all information, follow manufacturer service procedures, use proper tools and safety equipment, and consult a qualified repair shop when needed.