hard pedal

1996 FORD RANGER
20,000,000 MILES • 2.3L • 4 CYL • 2WD • MANUAL
Avatar
STEVEN SANDERS
  • MEMBER
  • 1 POST
Replaced clutch disc only I have a hard pedal now like as if there no travel of the throw out bearing. i did notice when tightening the pressure plate the fingers were depressing a lot. why?
May 19, 2017 at 2:37 AM
Repair Safety Notice: This information is for general instructional purposes only. Vehicle repair can be dangerous. Verify all information, follow manufacturer service procedures, use proper tools and safety equipment, and consult a qualified repair shop when needed.
Advertisement
Avatar
HMAC300
  • CAR REPAIR CONTRIBUTOR
  • 48,601 POSTS
it can be because the pressure plate was worn as well especially if the fingers were uneven when it was tightened down. but check to see if it is a hydraulic problem first and try bleeding it. there are two different types of slaves. see pictures for instructions on both.
Images (Click to enlarge)
Attached Media
Attached Media
May 19, 2017 at 6:37 AM
Advertisement