2006 Saab 9-3 won't start after battery disconnect and dash disassembly.

2006 SAAB 9-3
116,000 MILES
Avatar
DIESEL3333
  • MEMBER
  • 5 POSTS
I disassembled the dash of my 9-3 while uninstalling an XM receiver and had disconnected the battery in the process to protect everything from an inadvertent short. I am now unable to close the windows or moon roof, not to mention the car won't start. I'm assuming that there is a security feature that is thwarting my efforts but I'm stuck in the water while I research a solution. Any suggestions or assistance will be appreciated. Thank you in advance.

Regards,
John
Apr 29, 2012 at 7:22 PM
Repair Safety Notice: This information is for general instructional purposes only. Vehicle repair can be dangerous. Verify all information, follow manufacturer service procedures, use proper tools and safety equipment, and consult a qualified repair shop when needed.
Advertisement
Avatar
ASEMASTER6371
  • CAR REPAIR CONTRIBUTOR
  • 52,796 POSTS
do you have a key fob??

Roy
Apr 29, 2012 at 7:25 PM
Advertisement
Avatar
DIESEL3333
  • MEMBER
  • 5 POSTS
Yes, I even tried replacing the battery in the fob and also put an additional charge on the battery to no avail.
Apr 29, 2012 at 7:29 PM
Avatar
ASEMASTER6371
  • CAR REPAIR CONTRIBUTOR
  • 52,796 POSTS
The anti-theft alarm is always armed using the remote control but can also be set to arm itself when the car doors are closed or when the boot lid is closed. The anti-theft alarm status can be checked with the LED mounted on top of the instrument panel. When the anti-theft alarm is triggered, the BCM will send a bus command, whereby the UEC (underhood electrical center) will activate the front direction indicators and the car horn. The rear direction indicators are activated by the REC (rear electrical center). The siren is activated directly by the BCM control module via the communication cable. The interior lighting will be switched on by the BCM when the anti-theft alarm is triggered.

seems the bcm controls this. try removing the cable again and sees if it re boots.

Roy




Apr 29, 2012 at 7:31 PM
Avatar
DIESEL3333
  • MEMBER
  • 5 POSTS
Some additional details, I pretty much had the entire dash disassembled (vents, stereo, HVAC controls, trim, speedometer cluster, etc. all removed). This is why I'm under the impression that it may be a security issue because the car was without issue prior to the disassembly.
Apr 29, 2012 at 7:31 PM
Avatar
ASEMASTER6371
  • CAR REPAIR CONTRIBUTOR
  • 52,796 POSTS
you need to verify all your connections back there. grounds are very important.

Roy
Apr 29, 2012 at 7:35 PM
Avatar
DIESEL3333
  • MEMBER
  • 5 POSTS
Thanks ASEMaster, I appreciate the tips. I just disconnected and reseated the electrical connectors to each device and still get the random clicking upon key turn and still no start. The gauges flutter and the lights flash somewhat randomly with lots of clicking noises from what sounds like underneath the car. I have the charger back on the battery in the event that this is due to a low battery charge.
Apr 29, 2012 at 7:57 PM
Avatar
ASEMASTER6371
  • CAR REPAIR CONTRIBUTOR
  • 52,796 POSTS
check the cables for being clean and tight

Roy
Apr 29, 2012 at 8:07 PM
Avatar
DIESEL3333
  • MEMBER
  • 5 POSTS
Cables checked and rechecked, battery charged, finally started. Thanks for the help.
Apr 29, 2012 at 8:38 PM
Avatar
ASEMASTER6371
  • CAR REPAIR CONTRIBUTOR
  • 52,796 POSTS
good job
Apr 29, 2012 at 8:51 PM
Avatar
PENDE019
  • MEMBER
  • 2 POSTS
Diesel3333 did you get your car running? Same thing is happening to my 2006 9-3. Removed the speedometer now it won't start. Exact symptoms your car has.
Apr 27, 2015 at 12:16 PM
Avatar
PENDE019
  • MEMBER
  • 2 POSTS
diesel3333 What did you do to get your car to start I have the same symptoms after replacing the dash
Apr 27, 2015 at 3:33 PM