Heater blower motor

Tiny
JCARR755
  • MEMBER
  • 2004 VOLVO S80
  • 6 CYL
  • FWD
  • AUTOMATIC
  • 145,000 MILES
I have a 2004 volvo s80. The heater blower only comes on intermitently. I turn it on the manual way it still works only sometimes its like that in automatic or manual mode. I'm not sure where that fuse is for the heater blower motor or the resistor. Can u tell me where its located and I will start from there
Sunday, November 21st, 2010 AT 1:02 AM

5 Replies

Tiny
BMRFIXIT
  • MECHANIC
  • 19,053 POSTS
Check and replace blower motor speed resister
located by the blower motor
Was this
answer
helpful?
Yes
No
+1
Sunday, November 21st, 2010 AT 1:10 AM
Tiny
JCARR755
  • MEMBER
  • 6 POSTS
Is that located under the passenger side dash behind the glove box
Was this
answer
helpful?
Yes
No
Sunday, November 21st, 2010 AT 1:17 AM
Tiny
JCARR755
  • MEMBER
  • 6 POSTS
How do you check to see if its bad they are pretty expensive
Was this
answer
helpful?
Yes
No
Sunday, November 21st, 2010 AT 1:20 AM
Tiny
BMRFIXIT
  • MECHANIC
  • 19,053 POSTS
Behind right side of dash, in HVAC unit
Image (Click to make bigger)
Thumb
Was this
answer
helpful?
Yes
No
Sunday, November 21st, 2010 AT 1:30 AM
Tiny
JCARR755
  • MEMBER
  • 6 POSTS
Is this how I go about replacing it?

Yes you remove it from inside the vehicle. Remove the two torx 25 screws holding the passenger side kick panel and remove the panel. Remove the glove box (8 torx 25 screws I believe). Disconnect the blower and remove the five torx 25 screws holding the blower assembly in the climate box. Then the motor is held into the assembly with a torx 25 screw and the control unit has two screws.
Was this
answer
helpful?
Yes
No
Sunday, November 21st, 2010 AT 1:41 AM

Please login or register to post a reply.

Related Blower Fan Resistor Content

VIEW MORE