Volvo S 60 2.4 D engine stall

2002 VOLVO S60
80,000 MILES • 5 CYL • FWD • MANUAL
Avatar
RIJAD
  • MEMBER
  • 1 POST
I have S 60 2.4 D 2002 for 4 years. Last couple months have serious problems with engine stall. I do some check and stall happens on 2nd gear on 4200 rpm, on 3rd gear at 3300 rpm (did not check for 1, 4 and 5 gear), and ENGINE SERVICE REQUIRED is on. But when I switch off engine, message disappeared and when I check engine again same thing happens again. I, local Volvo garage change Mas Air sensor without any success. Please help because I don’t have so much confidence in this garage.
Mar 13, 2011 at 12:48 AM
Advertisement
Avatar
RASMATAZ
  • CERTIFIED EXPERT
  • 75,992 POSTS
If its the CEL/MIL is coming On do below

Have the computer scanned for code/s-you have a problem within the engine management system that caused the CEL to turn on-This is your starting point of diagnosis,finding out what's going on.
Mar 13, 2011 at 12:54 AM
Avatar
RASMATAZ
  • CERTIFIED EXPERT
  • 75,992 POSTS
You need to find out what's causing the CEL/SES to come on-get the computer/TCM scanned for code/s if any present post them
Jun 8, 2012 at 11:00 PM
Advertisement
Avatar
HITIDDY
  • MEMBER
  • 4 POSTS
my s60 had a message on the dash , engine mangagement needs service , the revs wouldnt go over 1500 , running rough , the power down to 10 percent of normal.
took it to a local guy , his computer said , ECM module high resistance and fault on F1 and F2 , if I unhook the battery then hook uo again the car runs normally.
dont always get a message on dash
Jun 8, 2012 at 11:06 PM
Avatar
RASMATAZ
  • CERTIFIED EXPERT
  • 75,992 POSTS
Have him try to erase the code if it continues there's a problem within that circuit and further diagnosis is required to eliminate the problem or go back to the Volvo dealership and seek more advices-
Jun 8, 2012 at 11:11 PM