How do i replace the fuel pump on a 2002 4 cylinder 2.0 liter VW jetta?
Dec 30, 2010 at 4:09 PM
Replace fuel pump in a 2002 jetta
2002 VOLKSWAGEN JETTA
CJACKO57
- MEMBER
- 2 POSTS
Advertisement
EXOVCDS
- ✓ASE Certified Mechanic
- 1,883 POSTS
The fuel pump is located under the right rear passenger seat.
- lift rear seat and fold forward
- remove 3 Philips screws from access platea and remove plate
- remove harness plug from pump/sender cover (press clip and pull)
- remove fuel lines (press clips in and pull)
- remove large collar ring
- note alignment marks, two arrows pointing at each other
- lift up on sender cover and pull out pump (careful with float arm)
Install in reverse... if tank is full, syphone fuel through return line (fitting with arrow in)
Thomas
- lift rear seat and fold forward
- remove 3 Philips screws from access platea and remove plate
- remove harness plug from pump/sender cover (press clip and pull)
- remove fuel lines (press clips in and pull)
- remove large collar ring
- note alignment marks, two arrows pointing at each other
- lift up on sender cover and pull out pump (careful with float arm)
Install in reverse... if tank is full, syphone fuel through return line (fitting with arrow in)
Thomas
Mar 19, 2012 at 4:54 AM
Repair Safety Notice: This information is for general instructional purposes only. Vehicle repair can be dangerous. Verify all information, follow manufacturer service procedures, use proper tools and safety equipment, and consult a qualified repair shop when needed.