SPONSORED LINKS

Replacing the alternator

Tiny
BILLMBARNESJR
  • MEMBER
  • 2002 NISSAN PATHFINDER
  • 3.5L
  • V6
  • 4WD
  • AUTOMATIC
  • 100,000 MILES
I am trying to replace the alternator. I have remove all two belt. I have also remove the two screws that secure the alternator but it is still firm in place. What other thing do I need to remove? Should I remove the power steering pump that is just above the alternator also? What else can I do there is not much space around the alternator in this vehicle?
SPONSORED LINKS
Wednesday, September 30th, 2015 AT 10:52 AM

7 Replies

Tiny
HMAC300
  • MECHANIC
  • 48,601 POSTS
See picture for easier removal it is from one of our pros.
Image (Click to make bigger)
Thumb
Was this
answer
helpful?
Yes
No
+7
Thursday, October 1st, 2015 AT 12:09 PM
Tiny
RISHO
  • MEMBER
  • 2 POSTS
  • 2001 NISSAN PATHFINDER
  • 230 MILES
There is a small plastic wiring connector that is set inside a plastic sheath that I cannot figure out how remove. Please help.

Thanks,
Risho
Image (Click to make bigger)
Thumb
SPONSORED LINKS
Was this
answer
helpful?
Yes
No
Thursday, September 20th, 2018 AT 7:06 PM (Merged)
Tiny
JACOBANDNICKOLAS
  • MECHANIC
  • 109,874 POSTS
You see the small tang in the connector from the picture? Insert a small standard screwdriver and push it inward to release the clip while pulling upward.

Here is a guide that will show you the steps to replace the alternator and diagrams below to show what it will be like you car:

https://www.2carpros.com/articles/how-to-replace-an-alternator

Check out the diagrams (below). Please let us know if you need anything else to get the problem fixed.

Cheers
Images (Click to make bigger)
Thumb
Thumb
Was this
answer
helpful?
Yes
No
+3
Thursday, September 20th, 2018 AT 7:06 PM (Merged)
Tiny
RISHO
  • MEMBER
  • 2 POSTS
Thanks for your reply. Besides not having much room for hands and/or tools, I think I know which tab you are referring to. However, not sure which way to move or pry it. I do not really want to break it and the wires are so thin that I fear if I pull too hard they may snap.

In addition, I was wondering if the entire plastic connector comes out or just the inner part. It appears that the inner part has movable plastic little arms or tabs.

Thanks again.

Risho
Was this
answer
helpful?
Yes
No
Thursday, September 20th, 2018 AT 7:06 PM (Merged)
Tiny
JACOBANDNICKOLAS
  • MECHANIC
  • 109,874 POSTS
Once the tang has been released the entire plug will come out.
SPONSORED LINKS
Was this
answer
helpful?
Yes
No
Thursday, September 20th, 2018 AT 7:06 PM (Merged)
Tiny
DDPAYNE
  • MEMBER
  • 1 POST
  • 1993 NISSAN PATHFINDER
Six cylinder four wheel drive manual.

Just replaced my battery one week ago. While driving yesterday my emergency brake light and battery light came on and my temperature gauge pegged at hot. When I lifted the hood it sounded like the battery was boiling.
Was this
answer
helpful?
Yes
No
Thursday, September 20th, 2018 AT 7:06 PM (Merged)
Tiny
RASMATAZ
  • MECHANIC
  • 75,992 POSTS
If the battery is boiling best get to the alternator checked out fast. It is overcharging the battery and could explode.
Was this
answer
helpful?
Yes
No
Thursday, September 20th, 2018 AT 7:06 PM (Merged)

Please login or register to post a reply.

Related Alternator Replace/Remove Content

Alternator Replacement
VIDEO
Alternator Replacement
Instructional repair video
Alternator Replacement
GUIDE
Alternator Replacement
Got a red battery warning light on? This most likely means the alternator has gone out and needs a replacement. To confirm the failure use a voltmeter to test the alternator...
VIEW MORE

Sponsored links