after installing a brand new radiator, what would cause the thermostat housing to blow off and be destroyed?

2000 TOYOTA RAV4
4 CYL • FWD • AUTOMATIC
Avatar
LMOFFETT
  • MEMBER
  • 7 POSTS
Installed new radiator. refilled with anti-freeze. 1st: bottom radiator hose blew off clamp and all. re-installed. refilled with water, just to make sure all was good. thermostat housing blew off and broke into pieces.
Aug 31, 2011 at 9:01 PM
Advertisement
Avatar
KHLOW2008
  • ASE Certified Mechanic
  • 41,814 POSTS
  • ASE Certified Mechanic
There is excessive pressure in the system. If bleeding of system was not properly carried, it would overheat and result in excesive pressure in system. The thermostat housing could have been brittle due to previous overheating issues and the pressure and overheating caused it to disintegrate. Replace with new, bleed system and have leak down test performed to ensure the head gasket is not bad.
Aug 31, 2011 at 9:23 PM
Avatar
LMOFFETT
  • MEMBER
  • 7 POSTS
what's the procedure to 'bleed the system'? And how is a leak down test performed?
Aug 31, 2011 at 9:43 PM
Avatar
KHLOW2008
  • ASE Certified Mechanic
  • 41,814 POSTS
  • ASE Certified Mechanic
After installation of all components, fill up with coolant. Start and run engine for 5 minutes with radiator cap off. Top up if necessary. Stop engine. Top up coolant. Close radiator cap. Run engine till radiator fan comes on. Wait for engine to cool down. Remove radiator cap and recheck coolant level. Top up if necessary. If level is very low, you would need to repeat above process till level is constant.

Leak down test is performed by applying pressure to the system and checking if the pressure drops. A special tool is used for this process and some parts stores loans them out.
Aug 31, 2011 at 9:50 PM
Join 2CarPros for free, one of the most advanced car repair communities on the internet. From first-time drivers to seasoned mechanics, everyone is welcome to reply, share details, and get better answers. You can add a temporary image or video first; uploads are limited to 20 MB.
Ask a Free Question
Repair Safety Notice: This information is for general instructional purposes only. Vehicle repair can be dangerous. Verify all information, follow manufacturer service procedures, use proper tools and safety equipment, and consult a qualified repair shop when needed.