1999 FORD AEROSTAR
120,000 MILES
Avatar
ANONYMOUS
  • MEMBER
  • 1 POST
Alternator light comes on when you turn the fan switch on, no matter the seed of the fan ,motor blows air no wierd noise?
Dec 3, 2012 at 11:51 PM
Repair Safety Notice: This information is for general instructional purposes only. Vehicle repair can be dangerous. Verify all information, follow manufacturer service procedures, use proper tools and safety equipment, and consult a qualified repair shop when needed.
Advertisement
Avatar
CARADIODOC
  • CAR REPAIR CONTRIBUTOR
  • 34,308 POSTS
Most likely there's one defective diode inside the generator. That will reduce its maximum output to exactly one third of its rating, and that's not enough to run the entire electrical system. Have the system professionally load-tested. If one of the six diodes is bad, "ripple" will also be very high.
Dec 4, 2012 at 1:15 AM
Advertisement