bumper cover removal

1996 VOLKSWAGEN PASSAT
132,000 MILES • 4 CYL • FWD • MANUAL
Avatar
AEROSPARES
  • MEMBER
  • 53 POSTS
remove bumper cover VW Passat
Nov 19, 2010 at 1:36 AM
Advertisement
Avatar
JACOBANDNICKOLAS
  • ASE Certified Mechanic
  • 110,194 POSTS
  • ASE Certified Mechanic
The bumper cover is held on by plastic clips, screws... If you look under the vehicle, you will see them. Next, in the wheel opening, there are screws that hold it in place. Finally, under the spare tire area are (I believe) two bolts that hold it on too.

If you want my honest opinion, remove the bumper cover with the aluminum steel internal bumper. It is much easier.

Let me know if you have other questions.

Joe
Nov 19, 2010 at 1:50 AM
Avatar
AEROSPARES
  • MEMBER
  • 53 POSTS
Thank you for the quick reply, Joe. The reason I asked about removing the front bumper is because I am going to replace the engine with another. I will also replace the CV joints, and clutch, pressure plate, throw out bearing, etc.

I have removed the screws from the inner fender, also the grill, and lights. I did see what looks like a push type fastener, but it doesn't seem to push/pull out. If removing the bumper with the cover attached is easier, I will gladly do that.

Should I leave the transmission in, or remove it with the engine? Any pointers for removing the engine?

Thanks again,
gr
Nov 19, 2010 at 2:45 AM
Join 2CarPros for free, one of the most advanced car repair communities on the internet. From first-time drivers to seasoned mechanics, everyone is welcome to reply, share details, and get better answers. You can add a temporary image or video first; uploads are limited to 20 MB.
Ask a Free Question
Repair Safety Notice: This information is for general instructional purposes only. Vehicle repair can be dangerous. Verify all information, follow manufacturer service procedures, use proper tools and safety equipment, and consult a qualified repair shop when needed.