1991 CHEVROLET VAN
189,000 MILES
Avatar
HWB120240
  • MEMBER
  • 2 POSTS
4.3 V6 New starter, new 800 CCA battery. It was slow turning over and the battery was an old one so replaced it. Was tested first and needed to be. So, no change. Replaced cables. No change. New startert today and still the same problem. Turns over like the battery is low. But it is not. What else can cause the motor to turn over slowly instead of spinning right over?
Feb 7, 2013 at 8:15 PM
Repair Safety Notice: This information is for general instructional purposes only. Vehicle repair can be dangerous. Verify all information, follow manufacturer service procedures, use proper tools and safety equipment, and consult a qualified repair shop when needed.
Advertisement
Avatar
SATURNTECH9
  • CAR REPAIR CONTRIBUTOR
  • 30,869 POSTS
Corroded battery cables the ends and sometimes under the insulation battery acid leaks down the cables.Have you made sure the battery cables are clean and tight?
Feb 7, 2013 at 8:29 PM
Advertisement
Avatar
HWB120240
  • MEMBER
  • 2 POSTS
These are new cables
Feb 7, 2013 at 9:33 PM
Avatar
CJ MEDEVAC
  • CAR REPAIR CONTRIBUTOR
  • 11,004 POSTS



DAT'S MY #1 ANSWER TOO

SEE MY LINK

https://www.2carpros.com/questions/1996-chevrolet-tahoe-wont-start-sounds-dead-battery-jumpbox-get-same-reults

I'D RULE THAT STUFF IN MY LINK OUT COMPLETELY BEFORE TRYING OTHER STUFF

OTHER THINGS I CAN THINK OF IS

..........CABLE GAUGE IS TOO SMALL

..........INCORRECT STARTER

..........NEW BAD STARTER

.........STARTER TEETH TOO CLOSE TO FLYWHEEL....SHIMMING MAY HELP http://shop.advanceautoparts.com/webapp/wcs/stores/servlet/PartSearchCmd?storeId=10151&catalogId=10051&pageId=partTypeList&suggestion=&actionSrc=Form&langId=-1&searchTerm=starter+shim&vehicleIdSearch=20777&searchedFrom=header

..........MECHANICAL ISSUES---WATER IN CYLINDER--ETC

KEEP US POSTED

THE MEDIC
Feb 8, 2013 at 2:28 AM
Avatar
SATURNTECH9
  • CAR REPAIR CONTRIBUTOR
  • 30,869 POSTS
Also see if the engine turns over freely by hand.
Feb 8, 2013 at 2:39 AM